HOW TO replace or clean REAR BRAKE pads and discs on Peugeot Rifter, Citroen Berlingo III and more

Detailed tutorial about how to replace or clean rear brake pads and discs.

Rear discs (268 mm) - OEM: 1609582880 or 3642786
Rear pads - OEM: 1609000680 or INNER: 9819426180 OUTER: 9819426280

The procedure is the same for the Peugeot Rifter, as well as the Citroen Berlingo III, Opel (Vauxhall) Combo, Toyota Proace City Verso and Fiat Doblo. The car model in the video is Peugeot Rifter GT Line Long (L2), 1.5 BlueHDi 96KW / 130k, manual transmission M6.

0:00 Introduction (turn on subtitles in your language at the bottom right)
0:29 Do not disconnect the connector
01:01 Electronic parking brake (EPB) How to service?
01:35 Cleaning the brakes
05:21 Check the cuff
07:10 Graphite vaseline
07:16 Threadlocker
08:19 Outer and inner (piston)
10:26

#PSA #stellantis #peugeotrifter #rifter #howto #EPB #electronic #parking #brake #pads #discs #rotors #caliper #handbrake #rear #squeale #noise #piston #citroenberlingo #opelcombo #toyotaproacecityverso #fiatdoblo #replacement #repair #release #manually #DIY #carsandrepairs #tutorial #instruction @carsandrepairs

[marekowsianiecki]

Thanks for profesional and simple presentation of thr rear brake work Very good job

[jurajkumpan-urbantimberser]

You cannot apply grease on wheel hub because it is a friction joint. Hub must be mirror clean with lateral runout max 0, 01 mm. Disc must have lateral runout max 0, 04 mm. 6mm screw in disc 10Nm. Brake caliper support 100 Nm. Brake caliper 30 Nm, Electro motor housing on caliper InHeX 2x 10Nm. While pressing piston bleed out fluid throw bleeding screw. Not back in system

[silencio]

Zdravím, před výměnou jste měl ruční brzdu aktivovanou nebo odblokovanou? Díky za info.

[manudarko]

Dobrý den, je to poprvé a chystám se měnit zadní brzdové destičky. Chci se zeptat, zda byla ruční brzda aktivována při vypnutém vozidle nebo deaktivována za jízdy, když jste prováděli výměnu nebo údržbu zadních brzdových destiček. . Buďte opatrní, protože to není známo..

[st]

Hello, thank you for your videos. How to replace the glow plug in this vehicle, where is it on the engine?.. Because I just bought the vehicle. and I want to lubricate the glow plug connections with silicone oil. In my previous vehicle, it was stuck to the engine block and could not be removed.

[manudarko]

Hola es mi primera vez y voy a cambiar las pastillas de frenos trasera, mi duda es si el freno de manos quedo activado con vehículo apagado o desactivado con vehículo andando, atento ya que no se aclara esa parte..

[younesb]

Thank you for this video. No need to use a scanner to service the rear brake pad, didn't know that :D

[gintarastribulas]

Diesel filter replacement, brake fluid replacement, oil filter replacement
THANK YOU VERY MUCH 👍🤝

[SandraJohnson-ze]

Excellent video. Can you do video how to change engine coolant. Please please

[TheUnforgiven]

Great Video, Does this work in the same way on the Peugeot 208 and Opel Corsa 2020 and later models?

[GaetanoConte-gc]

Spiegazione ottima.
Salve volevo sapere è vedere come si sostituisce la sbarra distabilizzatrice ?

[Leff]

Great video. Thanks for the tools shown. Many car manufacturers strongly recommend that you do not lubricate the wheel bolts.

[Schillie]

Thank you for the vid. When you are counter-clockwise turning the piston against the new pads, you are also moving the brake disc freely. Do you have to keep turning counter-clockwise till the piston is pushing against the pads and the disc is fixed? Or do you have to stop before, so the disc can rotate freely?

[gilouriviere]

Super Vidéo, quelle clarté et quelles belles prises de vue!!! Merci mile fois.

[bartoszkosiorek]

Thanks for all these videos. Awensome work.

It would be great to add video how to make car quiter. For example by installing soundproof mat.

[nikobellic]

Thank you for this awesome video 👍
Could you please answer an important question for me? Was your EPB released at the time of disassembly? My EPB was released as i removed my brakes. After removing the EPB-Motor I turned the EPB screw a bit to completelly free the brake pads. Should I adjust something when I reattach my EPB-Motor or will the EPB-System adjust it itself?

[benkr]

Hello, before you start do you turn the handbrake on or off inside the car ?

[oleksandrmarchuk]

Hi my Peugeot partner 2020 signal auto P won’t start engine it’s electronic parking could you advise

[marekmarecki]

Dzięki za kolejny film 👍, może nagrałbyś jak wymienić płyn hamulcowy

[YURU_STRAZAU]

Спасибо за ролик !👍 Всё понятно и доступно 🤝