2015-2020 F150 Powerstop Z36 Complete Brake Kit Install

---------------------------------------------------------------------------------------------------------------------------------------

Front Brakes Factory Torque Specs
Caliper Anchor Plate Bolts: 184 lb-ft.
Caliper Guide Pin Bolts: 27 lb-ft.
Caliper Flow Bolt: 26 lb-ft.
Disc shield bolts: 159 lb-in.
Rear Brakes Factory Torque Specs (With Electronic Parking Brake)
Caliper Anchor Plate Bolts: 184 lb-ft.
Caliper Guide Pin Bolts: 27 lb-ft.
Rear Brakes Factory Torque Specs (Without Electronic Parking Brake)
Caliper Anchor Plate Bolts: 184 lb-ft.
Caliper Guide Pin Bolts: 24 lb-ft.

Electronic Parking Brake (EPB) Service Mode Activation
1. Set the ignition to ON.
2. Press and hold the accelerator pedal and place the EPB switch to the RELEASE (downward) position. Continue to hold the accelerator pedal and EPB.
3. Set the ignition to OFF then set the ignition to ON within 5 seconds. Continue to hold the accelerator pedal and the EPB switch.
4. NOTE: The EPB system will be deactivated, preventing parking brake application until service has been completed and service (maintenance) mode has been deactivated. The yellow EPB indicator will be illuminated and Maintenance Mode will display on the message center.
NOTE: When replacing rear brake pads in service (maintenance) mode, the brake caliper piston must be compressed into the caliper housing. The brake caliper piston does not have to be rotated while compressing the piston.
Set the ignition to OFF then release the accelerator pedal and EPB switch.
Electronic Parking Brake (EPB) Service Mode Deactivation
1. Set the ignition to ON.

2. Press and hold the accelerator pedal and place the EPB switch in the APPLY (upward) position. Continue to hold the accelerator pedal and the EPB switch.

3. Set the ignition to OFF then set the ignition to ON within 5 seconds. Continue to hold the accelerator pedal and the EPB switch.

4. NOTE: The EPB system will fully apply and release the parking brake to guarantee sufficient air gap between the rear brake pads and brake disc.

Release the accelerator pedal and the EPB switch
____________________________________________________________________________________
SUBSCRIBE AND FOLLOW

[tysonjames]

Personally, i think you should have shown how to put the vehicle in brake maintenance mode. It is simple and makes compressing the caliper much easier. This isn't a video for beginners, thats for sure.

[eguiartehomes]

The music. This is the most relaxing brake job I've ever watched. Love it.

[dwaynesurratt]

I was told that you had to put the truck into maintenance mode to do the rear brakes or you will screw up the electronic parking brakes. So you don’t need to ?

[timmckinney]

Only thing I would add is with the electronic parking brake you have to put the parking brake in maintenance mode.

[CulichorHimself]

I installed this same setup on my wife 2016 Sienna, I will never look back absolutely pleased with the stopping results, I don't know about percentage increasing power BUT I know the braking power is greater over OEMs

[No_nonsense]

Had a similar kit on my last F150, a 2011. They were definitely better than stock!

[toddburnham]

So easy to upgrade my 2015. Great for towing and much better than stock.

[markbulva]

Have the extreme kit on my 14. They are awesome and the rotors still look brand new and have no wear u can feel w a fingernail

[onlytrue]

I have on my 2018 they work pretty good

[Junkawayllc]

What’s the torque for the bolts front and rear?

[MEJB]

Do you have to clean the new rotors off with brake cleaner?

[rubberduckie]

With my brake pad and rotors it didn't come with instructions that would have been nice

[rocknrocko]

Almost fell asleep with that calming music. Those original front rotors look almost brand new... can I have them if your going to just toss them? Oh, for the rear brakes, just take an old wrench and grind it a little flat so it fits in there for that rear pin.

[chad]

Just did my rear brakes on 2021 and the power stop grease sent with the kit told me to apply grease to the shims on the back of the pads. I did not see this step in this video. Am I wrong?

[yondego]

Is it metric or standard? l heard both.

[michaelplomp]

Do you bleed them after installing them all or after each wheel.

[woffordsoverlandjourneys]

Great video buddy, that's gonna be a hell of a truck for some lucky viewer!!!

[investinghutler]

Has anyone swapped raptor brakes on a f150?

[mrcreditunion]

Have you read anything abt drilled and/or slotted discs not being great for off-roading?

[nathancauldwell]

Is there a difference between the rear rotors for the electronic vs the manual parking brake for a 2020 f150 stx?