1997 Detroit series 60 turbo replace part 1

Replacing blown out turbo charger, most of the engine oil went in the exhaust and some went in the air cooler and intake manifold.

[prevost]

I don’t think any shop would stand behind a repair on such a neglected engine. I wouldn’t. You know that as bad as the coolant was the liners are ticking time bombs.

[sierravortec]

Always look forward to see what you’re working on, it’s always something new. My favourite thing about your channel is the wide amount of repairs you do!

[drewpierce]

Gordon, You mentioned earlier that it was going to take some effort to remove that turbo, and you weren't lying. My patience would have been tested for sure.

[seanthompson]

Brilliant video giving you the to torque pressure for filter housing and sump plug

[jameskwak]

Turbo usually don't fail without some warning signs like compressor wheel rubbing the housing driver needs to pay better attention

[williamzoom]

Nice to see that new work area is paying for itself already!

[lnofgss]

Gordon, get that coolant flushed out. The liners can get pitted too. I don’t recall if it was one of your videos during your over haul, but I saw someone’s liner pitting. I’m no mechanic, but I’ve seen videos where the block is destroyed and starts leaking because of water being used. I just hope they do something, drain it, put something in there to clean it, and flush it out, and refill it.

[jameskwak]

Replaced my turbo myself wasn't as bad as your job but I wouldn't wanna do it again...glad to see your not slowing down and still putting out content keep it up if you can take care

[fafnir]

I enjoy the big rig repair videos the most.

[fizixx]

Looks like you've got your work cut out for you. Nice video, thanks for putting it up.

[billestep]

Air cooler and intake manifold is probably full of oil too.

[bigriorollin]

The part you are looking at starting at 5:28 where the turbo attaches...i have oil leak on the bottom side of that any cause for concern there? Had it checked out and they said it wasnt a big deal. Would like to add that there is no oil on either end of the turbo took pipe off both ends and it was dry.